Submitted by: Dan Matuschek
Recipe by: http://vegan28.tripod.com/recipes.html
Servings: 11 1/2-cup sausages
- 6 c. water
- 1 ½ c. soy flour
- 1/4 c. white vinegar
- 1 c. hot water
- 1 ½ c. water
- 1 vegetable bouillon cube
- 1/2 t. salt
- 2 t. browning sauce (vegan)(optional)
- 1/2 c. cracked bulgur wheat
- 2 T. olive oil (optional) (only adds about 10 calories to each sausage)
- 1 ½ c. vital wheat gluten
- 3/4 t. onion powder (not flakes)
- 1/2 t. caraway seeds
- 1/2 t. ground marjoram
- 1 1/2 t. black pepper (coarsely ground)
- 1/4 t. allspice
This was the first of my pressure cooked vegan seitan sausages that was
specifically formulated to be fairly high protein, low in carbohydrates and fat.
I cooked the first test batch in my pressure canner just to speed up the
process. What I discovered is that pressure-cooking seitan has the same
desirable effects that it has on other foods, an even cooking throughout for a
consistent texture, and vary little dilution of flavors compared to other moist
cooking techniques. The result is a vegan sausage that in my opinion is superior
to the store bought versions that tend to be very dry, oil soaked and salty. For
best results, the sausage in this recipe need to be cooked in a pressure cooker
or pressure canner. They may, however, be formed into patties and baked on a
lightly oiled sheet tray, giving them more of a burger texture if you like. I
highly recommend that you try the intended pressure-cooking method.
Start by making whole grain tofu.
Bring to boil in a saucepot;
6 c. water
Add the soy flour, whipping until dissolved. Reduce heat to low, do not cover,
as it will boil over quickly.
Separately in a small bowl or measuring cup mix the white vinegar and 1 c. hot
Rapidly stir the soy flour mixture in a circular motion with a large spoon.
Stop stirring and immediately pour the vinegar mix into the center of the soy
mix with a steady even flow. Allow the pot to sit about 10 minutes uncovered and
undisturbed at the lowest heat setting to allow the tofu curds to coagulate.
Turn off the heat if you start to see more than a few bubbles. Too much
agitation causes the curds to break as they form. Let the pot set another 10
minutes, then gently scoop out the liquid and tofu with a large ladle into a
large, small holed colander. Allow the tofu to drain for at least 10 to 15
minutes. Tilt the colander and let it rest at an angle propped against the side
of your sink (or the large pot it came out of) Rotate the colander every several
minutes so that it will continue to drain while you prepare the rest of the
Bring 1 ½ c. water to boil in a small saucepot.
Add the vegetable bouillon cube, salt, browning sauce, cracked bulgur wheat, and
olive oil. Remove from heat and set aside for about 10 to 15 minutes to hydrate
the bulgur and allow it to cool, then spoon into a large bowl or pot.
Separately mix the wheat gluten with the remaining ingredients until well
blended, then add about 1/2 cup or so at a time to the bulgur mixture.
Cut 5 pieces of aluminum foil about 7 inches long. (Regular 12 in. wide roll)
Using a ½ c. measure, portion the mix by packing in firmly and leveling off the
top with your palm, and drop (or scoop) them side-by-side on the foil. Shape
them into sausages about 4 ½ inches long with a slight gap between them so that
they can be separated after cooking. You need to leave about an inch on each end
to allow room to close in the ends of the foil. Roll the foil away from you up
and over the sausage and slightly tighten the sausage by gently pulling the roll
towards you while holding the far edge of the foil in place with your other
hand. Continue to roll the sausage away from you to the end of the foil. Fold in
the ends (or twist) to seal the tube shaped package. Continue the process until
all of the sausages are made. If your cooker is too small to have the sausages
two wide, they can be wrapped individually.
Set the rack in the bottom of your pressure cooker or pressure canner and add
hot water to a depth of about two inches. Align the foil-covered sausages across
the bottom in the water. Lock the cover into place and cook at 15 # pressure for
15 minutes Use the rapid cooling method if allowed or recommended by the
manufacturer of your cooker. Read and follow the instructions given with you
pressure cooker / canner exactly.
Remove the sausage from the cooker with tongs allowing to drain by holding
them up by one end for a few seconds. To serve, place unwrapped sausage in a
nonstick pan and spray the sausages lightly with oil. Cook over a medium heat
turning frequently until hot and well browned. Eat them on a plain plate, or on
a bun with your favorite toppings.
back to fatfreevegan.com